Things you need to get started: The E4OD and 4R100 transmission system holds almost 18 quarts of ATF, and you must waste a couple of quarts to be sure you get it all purged and replaced, so buy 20 quarts of MERCON ATF [For the 4R100, use MERCON V].
What transmission fluid do I need for a 4R100?
fords reccomended fluid for the 4R100(E4OD) is standard mercon(dextron III). if you are going to use anything else go with a name brand full synthetic that is compatable with mercon…
How many quarts does a transmission flush take?
A typical fluid change will require anywhere from 3 to 6 quarts of ATF depending on the application, a new filter and a pan gasket (or RTV sealer) for the transmission pan.
How do you check 4R100 fluid level?
Apply service brakes, shift trans to NEUTRAL, set the parking brake, and leave engine running at curb idle speed. Add fluid until the fluid is in the hash marks. Insert dip stick and check fluid level. If level is low, add fluid to bring level to MIN mark on the dipstick.
How long will a 4R100 transmission last?
I consider the life of a 4R100 to be about 120K miles. If this truck you are looking at has 200K, them most likely it has had a new transmission at some point. I’ve heard of them lasting that long, but not very often. If it breaks, it will cost around 2000-2500 for a shop to rebuild it for you.
Can I use Mercon LV in my 4R100?
Premium Member. DO NOT USE MERCON V IN A STOCK 4R100 (all you have to do is read your owners manual to know this) If the seals have been changed in a rebuild it’s OK but, as alaskan155 correctly points out, it’s a Bad Idea for our stock transmission.
Why You Should Never flush your transmission fluid?
Pressure flushing can cause aging seals to start leaking. When it leaks more than a quart it could burn up the unit. Flushing does not cause the transmission to fail but it may speed up the process because it pushed metal particles back through the system.
Is it better to flush or drain transmission fluid?
Proponents of transmission flushes will often argue that a flush is a better service because it replaces more of your transmission fluid. It’s true that removing your transmission pan or draining your transmission via its drain plug (as your car manufacturer intends) only removes about 70% of the fluid inside.
How long does transmission fluid last in the bottle?
-BobtheOilGuy.com recommends a shelf life of 2 years max under protected conditions. Does not apply to previously OPENED bottles.
What’s the difference between E4OD and 4R100?
The Ford E4OD and 4R100 four-speed automatic transmissions were essentially the same transmission with different names. Ford also matched the 4R100 with larger diesel-powered engines. … The E4OD replaced the venerable Ford C-6 automatic transmissions.
Will a E4OD interchange with a 4R100?
All E4OD pumps are completely interchangeable. In 1998, Ford intro- duced the 4R100; one of the four pumps made for this unit is inter- changeable with the E4OD pump — as a complete assembly.
Is the 4R100 a good transmission?
The 4R100 is a computer controlled 4-speed automatic with a 1,000 lb-ft capacity from the factory. … However, like any high-mile automatic transmission, your 4R100 is sure to have some wear that should be addressed before you pump more power through it. Though it’s a good transmission, the 4R100 can be made be better.